Ford Sierra

1982-1993 of release

Repair and car operation



Ford Siyerra
+ 1.2. Car identification
+ 2. Maintenance
+ 3. General data
+ 4. Engines
+ 5. Coupling
+ 6. Transmissions
+ 7. Driveshaft and back bridge
- 8. Steering
   8.1. Technical characteristics
   8.2. Removal and installation of steering transfer
   8.3. Dismantling and assembly of steering transfer
   8.4. Removal and installation of a steering column
   8.5. Dismantling and assembly of a steering wheel
   - 8.6. A steering with the hydraulic booster
      8.6.1. Technical characteristics
      8.6.2. Removal and installation of steering transfer
      8.6.3. Removal and installation of the hydraulic pump
      8.6.4. Dismantling and assembly of a steering CAM GEAR broadcast
      8.6.5. Dismantling and assembly of a steering ZF broadcast
      8.6.6. Removal and installation of a steering column
      8.6.7. Dismantling and assembly of a steering wheel
      8.6.8. Air removal from steering system
+ 9. Suspension brackets
+ 10. Brake system
+ 11. Body
+ 12. Electric equipment






8.6.8. Air removal from steering system

PERFORMANCE ORDER
1. To unscrew a stopper of filling of oil in steering system with the hydraulic booster and to check oil level in system (at cold oil). In case of need to add oil to necessary level.

Prevention

Oil should be added slowly and it is impossible to shake capacity not to allow formation of vials of air in a tank.


2. To disconnect a negative wire (plug "1") from the ignition coil.
3. Several times to include a starter (each time approximately for 2 seconds), rotating at the same time steering wheel from an emphasis against the stop and adding all the time oil (the help of other person is necessary) before stabilization of level of oil in a tank and till the moment when oil will cease to leave air vials.
4. To check oil level, in case of need to fill its quantity and to screw up a stopper.
5. To connect an electric wire to the ignition coil.
6. To execute a trial trip and after a stop of the car to check tightness of connections of system of a steering with the hydraulic booster.
7. Finally to check oil level in a tank at warm oil of system of a steering with the hydraulic booster.