Ford Sierra

1982-1993 of release

Repair and car operation



Ford Siyerra
- 1.2. Car identification
   1.3. Car lifting
   1.4. Towage
   1.5. Combination of devices
   1.6. Cowl
   1.7. Engine start
   1.8. Lighting and alarm system
   1.9. Replacement of bulbs
   1.10. Ventilation and salon heating
   1.11. Doors
   1.12. The hatch and a luggage carrier on a roof
   1.13. Seats and head restraints
   1.14. Mirrors
   1.15. Control bulb of a pristegivaniye of seat belts
   1.16. Wheel replacement
+ 2. Maintenance
+ 3. General data
+ 4. Engines
+ 5. Coupling
+ 6. Transmissions
+ 7. Driveshaft and back bridge
+ 8. Steering
+ 9. Suspension brackets
+ 10. Brake system
+ 11. Body
+ 12. Electric equipment






1.5. Combination of devices

GENERAL INFORMATION

Combination of devices of the version C and CL

1–control bulb of pressure of oil,
2–control bulb of a battery charging,
3, 4 – the index of temperature of cooling liquid and an alarm system bulb about
overheat of the engine,
5–bulb of the alarm system of inclusion, hand brake and too low level of brake liquid,
6–control bulb, anti-blocking system (ABS),
7–index of level of fuel and control bulb of a reserve,
8–control bulb of preliminary warming up of the engine,
9–tachometer,
10-speedometer,
11-button of zeroing of the daily counter of kilometers,
12-control bulb of indexes of turns,
13-control bulb of headlights of a driving beam,
14-control bulb of emergency fires

Combination of devices of the GL version

1–control bulb of pressure of oil,
2–control bulb of a battery charging,
3, 4 – the index of temperature of cooling liquid and an alarm system bulb about an overheat of the engine,
5–bulb of the alarm system of turning on of the hand brake and too low level of brake liquid,
6–control bulb of anti-blocking system (ABS),
7–index of level of fuel and control bulb of a reserve,

8–control bulb of preliminary warming up of the engine,
9–tachometer,
10-speedometer,
11-button of zeroing of the daily counter of kilometers,
12-control bulb of indexes of turns,
13-control bulb of headlights of a driving beam,
14-control bulb of emergency fires

Place of the driver

1–switch of back fog lights,
2–switch of heating of back glass,
3–combination of devices,
4–rychazhok of adjustment of temperature and direction of giving of air,
5–hours with a digital board,
6–handle of adjustment of a nozzle of system of ventilation,
7–bulb of the alarm system of an overheat of the engine,
8–control bulb of initial heating of the diesel engine,
9–adjustable nozzles of system of ventilation,
10-a place for a radio receiver,
11-ashtray,
12-balancing of loudness of loudspeakers,
13-lighter,
14-switch of the fan,
15-switch of screen wipers and washers of glasses,
16-switch of lighting of salon,
17-the ignition switch with blocking of a steering wheel,
18-button of a sound signal,
19-switch of emergency fires,
20-multipurpose switch (indexes of turns, headlights of a driving and passing beam, light signal),
21-handle of adjustment of intensity of illumination of the forward panel

Control bulb of pressure of oil

The control bulb of pressure of oil lights up after inclusion of ignition and should go out after engine start. Switching off of a control bulb designates that pressure of oil the normal. If this bulb burns at the working engine or will light up during movement, it is necessary to stop immediately the car and to switch off the engine. Two minutes later it is necessary to check oil level in the oil pallet (see subsection 2.3) and in case of need to add its quantity.

If oil level normal, and a control bulb again lights up after engine start, it is necessary to switch off the engine and to tow off the car for check and repair of system of greasing of the engine.


Prevention

It is impossible to allow operation of the engine at a burning control bulb of pressure of oil.


Control bulb of a battery charging

The control bulb of a battery charging lights up after inclusion of ignition and should go out after engine start at a battery charging. Fire of this bulb at the working engine designates malfunction of a contour of a battery charging. During movement in that case it is necessary to stop and check integrity and a tension of a maple belt of a drive of the generator.

If the belt in a good condition and its tension normal, and a control bulb is still shone at the working engine, it is necessary to check a battery charging contour. It is possible to continue movement to the next service station, however, it is necessary to limit to a minimum consumption of electric energy from the accumulator, having switched off everything superfluous consumers of a current who are not required by traffic regulations.

The index of temperature of cooling liquid and alarm system bulb about an engine overheat

In the course of normal operation of the car of the shooter of the index of temperature of cooling liquid should be on the average, a white range of a scale.

If the arrow moves on a red site of a scale, and the alarm system bulb about an overheat of the engine will light up, it is necessary to stop immediately the car and to switch off the engine.

If the bulb is shone, and the arrow of the index is in an initial range of a scale (the engine cold), it can mean too low level of cooling liquid. If level normal, and after engine start a bulb again signals about an engine overheat, it is necessary to address for the help on service station.


Prevention

It is impossible to continue movement with being shone bulb of an overheat of the engine as it threatens with serious damage of the engine.


Bulb of the alarm system of turning on of the hand brake and too low level of brake liquid

Lights up, if the lever of the hand brake is not completely released (the hand brake is not switched off).

Also lights up, if level of brake liquid in a tank the too low. It is necessary to check level of brake liquid and to fill its level to the sign "MAX". Need of frequent completion of level of brake liquid testifies to a leakage of hydraulic system. It is necessary to address for the help on service station.

Control bulb of anti-blocking system (ABS)

In versions of the cars equipped with anti-blocking system simultaneous fire of control bulbs of ABS system and too low level of brake liquid means that in hydraulic knot of management of anti-blocking system (ABS) there was a pressure drop.

If only the control bulb of anti-blocking system (ABS) lights up, it is necessary to stop the car, to switch off ignition and a minute later again to start the engine. If the control bulb after start of the engine or during movement again lights up, it means that the electronic actuation device of anti-blocking system registered malfunction of system.

In both cases (too low level of brake liquid and malfunction of anti-blocking system) it is necessary to address immediately for the help on service station.

Index of level of fuel and control bulb of a reserve

The index shows, also after ignition switching off, approximate amount of fuel in a fuel tank of the car. When it is on a red site of a scale, it means that fuels in a tank there were less than 8 dm3. It in addition confirms fire of a control bulb.

Control bulb of preliminary warming up of the engine

This bulb lights up after ignition inclusion, when the engine cold. Its switching off means that glow plugs are warmed up to the level doing by possible start of the diesel engine. At once after switching off of a bulb it is necessary to start the engine.

Tachometer

Shows number of turns of a cranked shaft of the engine expressed in thousand revolutions per minute.

Speedometer

Specifies speed of movement in kilometers per hour. Besides, contains the counter of the kilometers passed by the car since the beginning of operation, and also the daily counter of kilometers specifying number of kilometers, passable from the moment of the last zeroing of the counter.

Button of zeroing of the daily counter of kilometers

The pressing this button causes zeroing of indications of the daily counter of kilometers.

Control bulb of indexes of turns

Blinks after inclusion of the index of turn. If frequency of a blinking considerably increases, it means that one of bulbs of indexes of turn does not burn.

Control bulb of headlights of a driving beam

Lights up after inclusion of headlights of a driving beam.

Control bulb of emergency fires

Lights up after inclusion of emergency fires.

Bulb of the alarm system of wear of brake shoes

At some versions of equipment of cars there is a bulb of the alarm system of wear of brake shoes which lights up when brake overlays of disk brakes of forward wheels wear out till thickness of 2 mm. It means need of the fastest replacement of brake shoes for brakes of both forward wheels (4 pieces).


Prevention

The bulb of the alarm system of wear of brake shoes lights up after inclusion of ignition and dies away only after single pressing a brake pedal, confirming, thus, the correct functioning of its contour.


Forward panel

Forward panel of the Ford Sierra car (the base version)

1–switch of fog lights,
2–heating of back glass,
3–zeroing of the daily counter of kilometers,
4–daily counter of kilometers,
5–speedometer,
6–total counter of kilometers,
7–control bulb of level
brake liquid and inclusion of the hand brake,
8–control bulb of pressure of oil,
9–control bulb of a pristegivaniye of seat belts,
10-control bulb of inclusion of headlights of a driving beam,
11-control bulb of a battery charging,
12-index of level of fuel,
13-control bulbs эконометра (index of the current fuel consumption),
14-average nozzles of system of ventilation,
15-hours with the strelochny dial,
16-niche,
17-handle of adjustment of a lateral nozzle of system of ventilation,
18-multipurpose switch (indexes of turns, headlights of a driving and passing beam, light and sound signals),
19-control bulb of indexes of turns,
20-switch of emergency fires,
21-the index of temperature of cooling liquid,
22-the ignition switch with blocking of a steering wheel,
23-lever of the switch of external lighting,
24-switch of a screen wiper and washer of a windscreen,
25-lever of the hand brake,
26-lever of gear shifting,
27-lighter,
28-switch of the fan,
29-ashtray,
30-rychazhok of adjustment of temperature,
31-rychazhok of adjustment of the direction of giving of air,
32-a ware box with the lock,
33-loudspeaker lattice

Forward panel of the Ford Sierra car (complete additional equipment)

1–switch of lobbies
fog lights,
2–switch of back fog lights,
3–heating of back glass and external rear-view mirrors,
4–switch of a screen wiper and washer of back glass,
5–speedometer,
6–total counter of kilometers,
7–daily counter of kilometers,
8–zeroing of the daily counter of kilometers,
9–index of level of fuel,
10-the index of temperature of cooling liquid,
11-control bulb of indexes of turns,
12-control bulb of a battery charging,
13-control bulb of level of brake liquid and inclusion of the hand brake,
14-tachometer,
15-rychazhok of adjustment of temperature,
16-average nozzles of system of ventilation,
17-rychazhok of adjustment of the direction of giving of air,
18-programmator of a screen wiper of a windscreen,
19-display of the module of graphic information,
20-handle of adjustment of a lateral nozzle of system of ventilation,
21-handle of adjustment of intensity of lighting of the forward panel,
22-multipurpose switch (indexes of turns, headlights of a driving and passing beam and light signal),
23-control bulb of inclusion of headlights of a driving beam,
24-a control bulb of pressure of oil, 25 – the switch of emergency fires,
26-button of a sound signal,
27-the ignition switch with blocking of a steering wheel,
28-switches of management of glasses of the left lateral lobbies (left) and back (right) doors,
29-lever of the hand brake,
30-the switch of giving of a current to switches of management of glasses of back lateral doors,
31-switches of management of glasses of the right lateral lobbies (left) and back (right) doors,
32-lighter,
33-switch of heating of sitting of the driver,
34-lever of gear shifting,
35-balancing of loudness of loudspeakers,
36-ashtray,
37-switch of heating of forward right sitting,
38-a niche for recorder cartridges,
39-switch of the fan,
40-lever of the switch of a screen wiper and washer of a windscreen,
41-lever of the switch of external lighting,
42-radio receiver,
43-a ware box with the lock,
44-lattice of the loudspeaker,
45-lateral nozzle of system of ventilation,
46-niche,
47-hours with the strelochny dial,
48-indicator of a multipurpose electronic clock